Ford Ranger Forum - Forums for Ford Ranger enthusiasts!

Go Back   Ford Ranger Forum - Forums for Ford Ranger enthusiasts! > >
Forgot Password? Join Us!

Welcome to Ford Ranger Forum

Reply
 
Thread Tools Search this Thread

  #1  
Old 08-15-2017, 11:56 AM
b2young b2young is offline
Learning to use the forums
 
Join Date: May 2016
Posts: 6
Default Oil leaking from bell housing ('92 4.0L 4x4 manual trans)

I have a '92 4x4 4.0L (6cyl....or is that a given with the 4L?); manual transmission, manual locking hubs (or are those a given.....?). It's over 165K miles now....didn't drive much in first dozen years.

Had new clutch last year (I posted about the situation when the clutch 'went out' on the fwy after a 500 mile drive....about 20 miles from home). New transmission back around 2006 or so.

Has been needing a quart of oil around every 1500 miles or so.

Sunday morning I noticed 'fresh' (but very black) oil drops on garage floor. Not much, but more than in the recent past. (Just completed a road trip couple of weeks ago, from home (Idaho) through Utah, Colo, NM, AZ, NV, CA and back home....used about 2 qts of oil during the trip--well, added two qts, one before leaving home, one in California, so the second qt is still mostly there.)

Not knowledgable enough to know if it's engine oil or something else; it seems to only come from where the bell housing (?) joins the engine...no sign of same fluid above the drip--ie, doesn't seem to come from above the transmission or on the engine. Drove about 70 miles on steep dirt roads Sunday after noticing the drip. Parked all day Monday...no new drops on floor, but one drop clinging to bottom of transmission where it meets the engine.

I've seen posts about the rear main seal being a potential problem; if that's my problem, is it engine oil, rather than transmission fluid? And, if it's only dripping a few drops a day (but sometimes I can see fresh drips below the engine when I'm in commercial parking lots, as I did Sunday (two days ago) after noticing the drops at home), is there much to worry about?

And if it's motor oil, is it related to the oil consumption I noted above? About a qt every 1500 miles....

I also saw there may be a remedy in some kind of oil/treatment that's supposed to help stop or minimize "main seal" leaks. Recommendations?

Any assistance would be appreciated. Could take it to my mechanic around the corner, but then I'd have to pay to find out the same answers you might be able to provide; mostly wondering if it may be the simplest problem....a small oil leak. (I'm guessing I might need an oil change.....from the blackness of the oil on the floor....)
__________________
1992 Ranger XLT 4x4 4.0L; nothing else special about it. (I am in love with it....but I know nothing about engines/transmissions or other stuff relating to repairing my baby.)

I've had this truck since birth.....just a tad over 155,000 miles on it (I bought it and lived in Alaska for 20 some-odd years and there weren't many places to drive.....)
Reply With Quote
  #2  
Old 08-15-2017, 12:08 PM
mattsnewl5 mattsnewl5 is offline
Ford Ranger Owner
 
Join Date: Jun 2017
Posts: 58
Default Re: Oil leaking from bell housing ('92 4.0L 4x4 manual trans)

Mine was doing the same thing and I have 5 speed 44 as well. I had work done on clutch and trans so I replaced my rear main while is wad in it. I personally don't believe in additives. Moral of story is th fix the seal, save $ on oil

Sent from my SAMSUNG-SM-J320AZ using Tapatalk
Reply With Quote
  #3  
Old 08-15-2017, 12:37 PM
b2young b2young is offline
Learning to use the forums
 
Join Date: May 2016
Posts: 6
Default Re: Oil leaking from bell housing ('92 4.0L 4x4 manual trans)

Thanks, Matthew!
__________________
1992 Ranger XLT 4x4 4.0L; nothing else special about it. (I am in love with it....but I know nothing about engines/transmissions or other stuff relating to repairing my baby.)

I've had this truck since birth.....just a tad over 155,000 miles on it (I bought it and lived in Alaska for 20 some-odd years and there weren't many places to drive.....)
Reply With Quote
  #4  
Old 08-16-2017, 09:35 AM
mattsnewl5 mattsnewl5 is offline
Ford Ranger Owner
 
Join Date: Jun 2017
Posts: 58
Default Re: Oil leaking from bell housing ('92 4.0L 4x4 manual trans)

No worries bud. Good luck!

Sent from my SAMSUNG-SM-J320AZ using Tapatalk
Reply With Quote
Reply

Tags
bell housing, oil leak, slow drip, very black

Thread Tools Search this Thread
Search this Thread:

Advanced Search


Similar Threads
Thread Thread Starter Forum Replies Last Post
Line Near Bell Housing Leaking Coolant 91_lowrange 4-Cylinder Tech 3 05-14-2016 09:08 AM
What all causes fluid in bell housing in a manual transmission gorrilla10101 Drivetrain Tech 3 11-20-2014 10:54 AM
leaking trans fluid between tail housing and transfer case Asprintree Drivetrain Tech 1 10-18-2012 08:44 PM
Help! Motor oil leaking out of bell housing davew0622 2.9 Liter Tech 4 04-08-2011 03:26 PM
leaking manual trans BLISTERBRAIN22 Drivetrain Tech 0 09-09-2009 05:21 PM