Ford Ranger Forum - Forums for Ford Ranger enthusiasts!

Go Back   Ford Ranger Forum - Forums for Ford Ranger enthusiasts! > >
Forgot Password? Join Us!

Welcome to Ford Ranger Forum

Reply
 
Thread Tools Search this Thread

  #1  
Old 09-12-2017, 06:23 PM
JAMMANICA JAMMANICA is offline
Craigslist is awesome
 
Join Date: Jun 2016
Posts: 472
Default Things they don't tell you about a V8 swap

Anyone that has done a V8 ranger, dreamed of doing or is in the process has read the TRS article "Swapping An Explorer 5.0L In To A 1998-Up Ranger"

I have some additions, things they left out that might be helpful.

They: "Using the Explorer 5.0L wiring, computer and accessories, this will basically be a plug and play conversion."

Add this: "after you have done it 3 or 4 times"


They: "The two biggest problems you could run in to doing this swap would be the PATS and VSS."

Add this: "There will be tens of dozens of little problems you will face also"

They: "The easiest V8 donor for a 1998-2007 Ranger 4x4 swap would be the 1996-2001 Explorer/Mountaineer 5.0 AWD."

Some big additions:

"Remember if your donor vehicle has power windows and power seats to move the seat all the way back to be able to easily access under the dash, also roll the windows up before removing the battery and wiring harness. Failure to do so will result in animals making homes inside, mammals as well as stinging insects especially if you leave it sitting for most of a year in an open field."

"If you leave the transmission in the donor and pull the motor only, do not remove the transmission dip stick tube until you have everything you want to remove by crawling under the vehicle first. Having 10 gallons of floor dry or kitty litter works also but not as easy."

"The temperature sensor for the overhead console is not necessarily in the spot that every article on the internet says it is. It might just be on the driver side."

"The most likely place for a huge mud based wasp nest it behind the dash to the right of the instrument cluster. Being able to run quickly will minimize bodily damage. There might also be additional hornet nests in the door panels if you leave them open."

Now on the vehicle the motor is being installed in.

"Make sure you are not following the 4 wheel drive V6 tutorial if doing a coil spring 2WD ranger born with a 4 cyl, you will waste a lot of money on wrong mounts, wrong plates and general headaches on every detail. Good luck finding 100% reliable info on the coil spring swaps even from people who design the mounting plates. Plan on spending 3 or 4 times the money you budgeted, plan on it taking at least 10 times longer than the articles you will read."


Maybe eventually I will finish it. I hope.
__________________
00 XLT 4WD XCSB 4.0 my new baby
00 XLT 2WD RCSB 5.0 swap in progress.
98 XLT 4WD XCSB 4.0 dead
99 EXPO donor motor for dead one and parts for the others.
97 Mountaineer stripped donor for 5.0 project and other things
Reply With Quote
  #2  
Old 09-17-2017, 10:15 AM
win win is offline
Ford Motor Co
 
Join Date: Feb 2014
Posts: 168
Default Re: Things they don't tell you about a V8 swap

For me, the $550.00 custom 2 piece driveshaft was the big surprise.

I'd waded through wiring diagrams till my eyes bled. Read and researched as much as I could. Savaged a couple wrecks in a breakers yard for the wiring plugs so I could make wiring adapters to make the conversion as plug and play as possible.

The entire swap went really well, but it took as long to get the driveshaft made as it did for the rest of the swap and the cost of the shaft was shocking.

Guess I should have said I was swapping in an old Pinto 2.0 and only needed a driveshaft for an 80 hp drivetrain.
Reply With Quote
Reply

Thread Tools Search this Thread
Search this Thread:

Advanced Search


Similar Threads
Thread Thread Starter Forum Replies Last Post
done a few things blue4.0 Vehicle Snapshots 5 12-20-2014 11:01 AM
What do these things do? Hickfromhell88 4.0 SOHC / 4.0 OHV Tech 11 07-16-2012 12:52 PM
Want to Buy: some things to buy my ranger Exterior Parts 2 10-09-2011 03:01 PM
Do these things really top out at 86 Mph? Pool Runner General Ford Ranger Discussion 59 07-26-2011 10:44 PM
For Sale: A few more things to get rid of Clinton Exterior Parts 34 11-20-2010 10:34 AM